Physico-chemical properties of evaporated epa (40÷56% ) from phosphorites of the central Kyzylkum
Keywords:
Phosphorus, phosphorite, extraction phosphoric acid, concentration, purification, filtration, fertilizers, acid propertiesAbstract
The article presents a technology for producing high-quality phosphorus fertilizers by increasing the concentration of extraction phosphoric acid (EPA) obtained from low-grade phosphorites of the Central Kyzylkum Desert. Since impurities from phosphorite ore pass into the EPA and exceed permissible levels in the final product, purification and concentration of the acid are required. A two-stage evaporation method was used to obtain EPA with 25.13–27.5% P₂O₅. Four EPA samples and sixteen subsamples were analyzed to track changes in composition during concentration. Removing a magnesium-rich precipitate (40–46% P₂O₅) improves processability. Concentrated acids (45–55% P₂O₅) enable the production of high-quality mineral fertilizers.
References
Kaxarov E., Seytnazarova A., Alimov U.K., Kasimov D., Namazov S.S. Study of the Process of Calcium Feed Phosphate Fabrication by Thermal Acid Processing of Washed Dried Concentrate. E3S Web Conf., Vol. 491, 2024. International Conference on Environmental Development Using Computer Science (ICECS’24). https://www.scopus.com/authid/detail.uri?authorId=6602820598
Kurbaniyazov R.K., Khudoyberdiev J.H., Reymov A., Radjapov R., Seytnazarov A.R. Characteristics of Nodular Phosphorites of Karakalpakstan and Their Processing into Granular Simple Superphosphate. Izvestiya Vysshikh Uchebnykh Zavedeniy. Khimiya i Khimicheskaya Tekhnologiya, 68(1): 109–119, 2024. DOI:10.6060/ivkkt.20256801.7007. https://www.scopus.com/authid/detail.uri?authorId=6602820598
ГОСТ 20851.2-75. Методы определения содержания фосфора. Москва: Изд. стандартов, 1983. 22 с.
Винник М.М., Ербакова Л.Н., Зайцев П.И. и др. Методы анализа фосфатного сырья, фосфорных и комплексных удобрений, кормовых фосфатов. Москва: Химия, 1975. 218 с.
Ксльман Ф.Ы., Бруцкус Е.Б., Ошерович Р.Х. Методы анализа при контроле производства серной кислоты и фосфорных удобрений. Москва: ГосНТИ хим. лит-ры, 1963. 392 с.
Минеральные удобрения и серная кислота / Тр. НИУИФ. Москва, 1978. С. 100–102.
Kaxarov E., Kurbanova S., Mirzakulov G., Hasanov A., Saydaliyev O. Thermal Defluorinated Phosphates Based on Phosphorites of the Central Kyzylkum. BIO Web Conf., Vol. 141, 2024. IX International Scientific Conference on Agricultural Science 2024 “Current State, Problems and Prospects for the Development of Agricultural Science” (AGRICULTURAL SCIENCE 2024). https://www.scopus.com/authid/detail.uri?authorId=59148686500
Кивилис С.С. Техника измерения плотности жидкостей и твердых тел. Москва: Стандартгиз, 1969.
Бергман Л.Г., Лужная Н.П. Физико-химические основы изучения и использования соляных месторождений хлорид-сульфатного типа. Москва: Изд. АН СССР, 1951. 232 с.
Берг Л.Г. Введение в термографию. Москва: Наука, 1969. 368 с.
Бахриддинов Н.С. Жидкие комплексные удобрения на основе экстракционной фосфорной кислоты. Science Time, 2017, №5(41), С. 177–180.
Bakhriddinov N.S. Effect of Extraction Phosphoric Acid Evaporation Heat on Polymerization. Information Technology in Industry, 2021, Vol. 9, №3, С. 842–847.
Попов Н.П. и др. Концентрирование экстракционной фосфорной кислоты из Чилисайских фосфоритов. Реф. инф. сборник НИУИФ, 1976, Вып. 3, С. 5–8.
